Editing MembersPage/PoweredVolvo

 ##      
 ##      
 #####   
 ##  ##  
 ##  ##  
 ##  ##  
 ##  ##

         
 ##      
 ##      
 ## ##   
 ####    
 ## ##   
 ##  ##

 ##      
 ##      
 ##  ##  
 ## ##   
 ####    
 ## ##   
 ##  ##

         
  ####   
 ##  ##  
 ##  ##  
 ##  ##  
 ##  ##  
  ####

         
         
 ##  ##  
  ####   
   ##    
  ####   
 ##  ##

IMPORTANT: enter the case-INsensitive alphabetic (no numbers) code AND WRITE SOME SHORT summary of changes (below) if you are saving changes. (not required for previewing changes). Wiki-spamming is not tolerated, will be removed, so it does NOT even show up in history. Spammers go away now.

Visit Preferences to set your user name
Summary of change:
This car the Volvo S60 20V turbo 5 cyl. Your '''reference teeth setting''' was wrong. You need step of 24 (hexa 18), not 18 (hexa 12) Cranking log: http://www.vems.hu/files/MembersPage/poweredracing/datalog200811302136.xls new cranking log http://www.vems.hu/files/MembersPage/poweredracing/datalog200812011530.xls After setting ign outputs h[2], on the bench with 1.1.42 RPM was good and ignout was good. primep=00 primep_temp_scaling=34 cwl=2A cwh=11 cranking_thres=02 awev=3F awev_temp_scaling=00 awec=FF warmup_clt_range[0]=00 warmup_clt_range[1]=00 warmup_clt_range[2]=11 warmup_clt_range[3]=25 warmup_clt_range[4]=50 warmup_clt_range[5]=64 warmup_clt_range[6]=78 warmup_clt_range[7]=8C warmup_clt_range[8]=AA warmup_clt_range[9]=C8 warmup_clt[0]=C8 warmup_clt[1]=C8 warmup_clt[2]=AA warmup_clt[3]=8C warmup_clt[4]=82 warmup_clt[5]=7B warmup_clt[6]=78 warmup_clt[7]=6F warmup_clt[8]=68 warmup_clt[9]=64 warmup_rpm_scale=A8 req_fuel=14 divider=01 alternate=14 injopen=00 battfac=22 kpafac=97 kpaoffs=90 injocfuel=22 injrampup_battfac=FF injpwm=FF injpwmt=FF als_launch_input=C6 rpmk[0]=09 rpmk[1]=60 tpsdot_kpadot_conf=00 tpsdotrate[0]=04 tpsdotrate[1]=07 tpsdotrate[2]=0F tpsdotrate[3]=1A tpsaq[0]=0A tpsaq[1]=0D tpsaq[2]=0E tpsaq[3]=11 als_cut_mintps=FF tpsasync=88 acmult=0A tpsacold=0A launch_enrich=20 launch_retard=C8 overrun_fuelcut=11 overrun_fuelresume=0D rev_limit=53 airden_ignore=62 config11=41 config12=40 config13=0A batt_cal=C6 fastidle=C6 als_max_cut=40 dbaro=04 tps_low=3C tps_high=EA fan_temp=EA fan_hyst=05 fan_channel=FF iac_step_seq=D8 iac_conf=58 iac_max_steps=A7 iac_tps_thres=03 iac_cold_idle_temp=65 iac_warm_idle_temp=B4 iac_cold_rpm=69 iac_warm_rpm=61 iac_cold_start_pos=A8 iac_warm_start_pos=78 iac_afterstart_rpm=00 iac_afterstart_duration=14 iac_speed=00 iac_kp=1C iac_ki=15 iac_kd=21 launch_rpm=2C iac_integral_limit_dec=33 iac_integral_limit_inc=01 iac_integral_deadband=00 iac_deadband=00 als_cut_maxtps=0F iac_overclose_interval=C8 iac_ref_pos[0]=B8 iac_ref_pos[1]=B5 iac_ref_pos[2]=A3 iac_ref_pos[3]=8F iac_ref_pos[4]=8F iac_ref_pos[5]=8C iac_ref_pos[6]=8C iac_ref_pos[7]=8A iac_ref_pos[8]=8A iac_ref_pos[9]=8A iac_sol_channel=6F iac_ign_slope=14 softrpm_range=4B iac_ign_advance_limit=04 iac_ign_retard_limit=18 iac_ign_threshold=00 ego_conf=06 ego_lag=02 ego_coolant=7E ego_maxtps=E6 ego_maxmap=69 ego_minrpm=05 ego_maxrpm=46 ego_warmup=14 ego_lean_limit=0F ego_rich_limit=03 ego_pid_kp=1E als_enrich=00 ego_delta=03 ego_target=19 ego_pid_window=01 wbo2_warmup_ramp=FF als_react_tps=FF wbo2_abs_limit=E0 wbo2_limit_maxt=F0 wbo2_fallback=70 wbo2_retry_t=06 als_retard_rpm1=FF als_retard_rpm2=FF wbo2_ri_target=A5 wbo2_nernstdc_target=86 wbo2_pump_pw_zero=68 wbo2_calibration=CB wbo2_heater_pid_kp=45 wbo2_heater_pid_ki=11 wbo2_heater_pid_kd=1A wbo2_heater_pid_ilimit=80 wbo2_pump_pid_kp=15 wbo2_pump_pid_ki=4E wbo2_pump_pid_kd=00 wbo2_pump_pid_ilimit=FF wbo2_ri_confidence_scale=80 knock_chan=01 knock_sampling_window=F2 knock1_frequency=29 knock1_gain=0E knock1_integrator=14 knock2_frequency=29 knock2_gain=00 knock2_integrator=00 knock_threshold=0A knock_noise_scale=D8 knock_max_retard=18 knock_default_retard=00 knock_retard_step=04 knock_retard_delay=30 knock_advance_step=01 knock_advance_delay=50 knock_minrpm=0A knock_maxrpm=42 ve_learn_coolant=CF ve_learn_max_power=64 ve_learn_rpm_scale=28 ve_learn_kpa_scale=28 ve_learn_ego_scale=50 ve_learn_min_weight=14 ve_learn_speed=32 ve_learn_limit=80 ve_learn_conf=01 lcd_c0=FE lcd_delay=42 lcd_backlight=FF kpa_conf=22 als_igncut_rpm2=FF als_retard_mintps=FF als_retard_maxtps=FF lcd_default_view=00 primary_trigger=01 secondary_trigger=19 tooth_wheel=3A trigger_tooth=00 another_trigger_tooth=18 crank_minper=28 tooth_wheel_twidth1=18 tooth_wheel_twidth2=00 cam_sync_r_edge_phase=00 cam_sync_f_edge_phase=00 reset_engphase_after=40 ign_tdcdelay=A0 ign_dwell14=3B ign_dwell6=4A ign_crank_advance=24 ign_out=70 ignchmax=04 engine_off_delay=02 pump_on_mintime=04 fuelpump_channel=5F inj_stage2_rate=FF inj_stage2_start_tps=FF inj_stage2_start_map=FF als_igncut_rpm1=FF als_deact_time=00 als_deact_egt=00 als_retard=CC als_rev_limit=4E misc1out_minrpm=14 misc1out_maxrpm=51 misc1out_mintps=70 misc1out_maxtps=FF misc1out_minmap=3C misc1out_maxmap=87 misc1out_channel=7F misc2out_minrpm=FF misc2out_maxrpm=FF misc2out_mintps=FF misc2out_maxtps=FF misc2out_minmap=FF misc2out_maxmap=FF misc2out_channel=FF act_wot_rpm=FF act_wot_channel=FF act_rpm_rpm=FF act_rpm_channel=FF egt1_cal=4A als_tks_channel=FF boost_conf=59 boost_targetoffs=00 boost_minpressure=3E boost_pid_kp=FF boost_pid_ki=0B boost_pid_kd=80 boost_pid_ilimit=37 boost_channel=7F water_pump_temp=00 hybrid_rpm_a=00 hybrid_rpm_m=00 water_pump_hyst=7E water_pump_channel=FF toothrel_normal=76 toothrel_missing=00 fuelcut_min_kpa=06 fuelcut_max_kpa=95 tach_channel=0F tach_div=11 shiftcut_conf=A7 shiftcut_channel=FF shiftcut_time=6F softrpm_rpm=55 j[0]=5853 6F63 8583 8B88 888B 8283 4B48 5F62 857A 9695 9696 9696 j[1]=5952 6B52 857B 9493 9696 9696 6369 7062 8A7A 9797 9696 9696 j[2]=6E70 7C74 917E 9698 9696 9696 7F7D 8080 9694 9B9A 9696 9696 j[3]=8C8B 888E 9691 9B99 9696 969B 9895 9D9B A3A0 A0A2 9D9F 9A9C j[4]=9C99 A3A0 A9A6 ABAA ACAB A6A9 A19E A8A5 AFAC B2B0 B4B3 ADB1 j[5]=A6A2 AEAA B6B2 B9B7 BBBA B5B8 AAA6 B3AF BCB8 C0BE C3C1 BCC0 j[6]=3737 3737 3737 3737 3737 3737 3737 3737 3737 3737 3737 3737 j[7]=3737 3737 3737 3737 3737 3737 4848 4848 4348 4343 3D3D 373B j[8]=4F4F 4D4F 4D4D 4348 4343 3D3D 5555 4F51 4F4F 4D4D 4848 4343 j[9]=5555 5151 5151 4F4F 4F4F 4D4D 5555 5555 5555 5555 5555 5555 j[A]=5555 5855 5858 5858 5C58 5C5C 6363 6663 636B 6663 6D66 6D6D j[B]=7575 7575 7575 7E7E 877E 8787 7E7E 7E7E 8787 8787 8A87 8A8A l[0]=9A 9C 9D 9D 9D 9D 9C 98 35 35 66 8B l[1]=99 9B 9B 9B 9B 9C 9A 96 33 33 64 81 l[2]=90 95 96 98 97 97 95 8F 2E 30 5C 72 l[3]=80 86 8A 8D 8E 8E 8C 84 2E 2E 55 65 l[4]=6E 76 7A 7E 80 80 7F 78 2E 2E 49 58 l[5]=62 6A 6D 70 72 72 72 6A 2E 2E 40 4F l[6]=58 5D 61 64 66 67 65 5E 2E 2E 39 44 l[7]=4B 50 55 58 5A 5B 5A 53 2E 30 31 38 l[8]=3E 41 44 47 49 49 49 43 01 02 04 08 l[9]=10 00 83 C0 00 60 48 30 18 D0 00 00 l[A]=38 48 58 68 70 50 50 50 4B 4B 4B 66 l[B]=80 7E 7E 7E 7E 7D 7C 74 4D 66 80 99 n[0]=36 37 70 92 9B 9B 9B 9B 9B 9B 9B 98 n[1]=37 37 6E 90 9B 9B 9B 9B 9B 9B 9B 98 n[2]=37 37 6B 8F 9B 9B 9B 9B 9B 9B 9B 98 n[3]=37 37 68 8D 9A 9C 9D 9D 9D 9D 9C 98 n[4]=35 35 66 8B 99 9B 9B 9B 9B 9C 9A 96 n[5]=33 33 64 6D 90 95 96 98 97 97 95 8F n[6]=2E 30 5C 72 80 86 8A 8D 8E 8E 8C 84 n[7]=2E 2E 55 65 6E 76 7A 7E 80 80 7F 78 n[8]=2E 2E 49 58 62 6A 6D 70 72 72 72 6A n[9]=2E 2E 40 4F 58 5D 61 64 66 67 65 5E n[A]=2E 2E 39 44 4B 50 55 58 5A 5B 5A 53 n[B]=2E 30 31 38 3E 41 44 47 49 49 49 43 k[0]=0B 12 19 21 28 32 3F 4B 58 64 71 87 r[0]=B3 CC F0 FF 1C 21 27 2C 31 37 3C 45 h[0]=01 02 04 08 10 20 40 80 h[1]=00 60 48 30 18 00 00 00 even basic settings, like ign out are wrong (unless you use 4 stepper out and ignch7): '''h[2]=3E 4E 5E 6E 70 50 50 50''' You should upload correct tables ! Like h[2]=20 30 60 70 00 50 50 50 y[0]=FF FF FF FF FF FF FF FF FF FF FF FF y[1]=FF FF FF FF FF FF FF FF FF FF FF FF y[2]=FF FF FF FF FF FF FF FF FF FF FF FF y[3]=FF FF FF FF FF FF FF FF FF FF FF FF y[4]=FF FF FF FF FF FF FF FF FF FF FF FF y[5]=FF FF FF FF FF FF FF FF FF FF FF FF y[6]=FF FF FF FF FF FF FF FF FF FF FF FF y[7]=FF FF FF FF FF FF FF FF FF FF FF FF y[8]=FF FF FF FF FF FF FF FF FF FF FF FF y[9]=FF FF FF FF FF FF FF FF FF FF FF FF y[A]=FF FF FF FF FF FF FF FF FF FF FF FF y[B]=FF FF FF FF FF FF FF FF FF FF FF FF 1.1.27 ----------------------------------------------- Date: 2008.12.04. - 17:01:03 * Toothwheelwidth and h[1] reftooth table looks wrong. Toothwheelwidth avaible in primarytrigger page (f1 for info) and reftooth table in advanced tab. * your dwell is over 7ms, dwell Map to 00 or 01, confswitch 00, disable aim from lcd page. '''Read changelog and GenBoard/UnderDevelopment/FirmwareChanges * make sure h[2] is correct I say thank you for the help! The firmware a mistake may cause it that the trigger not good?
Optional: Add document to category:
Wiki formatting: * is Bullet list ** Bullet list subentry ... '''Bold''', ---- is horizontal ruler, <code> preformatted text... </code> See wiki editing HELP for tables and other formatting tips and tricks.